Larry H. Miller Ford Mesa

2019 Ford F-250 Super Duty Recall

Ford F-250 Super Duty Recall service at Larry H. Miller Ford Mesa in Mesa, AZ

SCHEDULE NOW Call Us View Specials

Frequently asked questions

Recall Summary

11 recalls found · All repairs FREE

Tire

FREE1 OPEN RECALL

NHTSA campaign 21V155000 · 15,769 vehicles affected

Defect

Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.

Consequence

Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.

Corrective Action

Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall is expected to begin March 29, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.

Tire1

FREE1 OPEN RECALL

NHTSA campaign 21V155000 · 15,769 vehicles affected

Defect

Consequence

Corrective Action

Axle Assembly1

FREE1 OPEN RECALL

NHTSA campaign 20V576000 · 9,628 vehicles affected

Defect

Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350, single rear wheel and dual rear wheel, 4X4 vehicles. The front axles may contain a wheel end yoke that was not properly welded to the axle tube end.

Consequence

An improperly welded axle may affect vehicle control, increasing the risk of a crash.

Corrective Action

Ford will notify owners and dealers will inspect the front axle wheel yoke weld location. If the weld is found to be inaccurately located, the axle assembly will be replaced free of charge. The recall is expected to begin November 9, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S56.

Steering1

FREE1 OPEN RECALL

NHTSA campaign 20E090000 · 102 vehicles affected

Defect

Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer through shaft" may block the piston ports

Consequence

If the steering locks, it can increase the risk of a crash.

Corrective Action

Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.

Structure Roof and Pillars1

FREE1 OPEN RECALL

NHTSA campaign 19V880000 · 490,574 vehicles affected

Defect

Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.

Consequence

A vehicle fire could result if materials ignite inside the vehicle.

Corrective Action

Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.

Tailgate Latch1

FREE1 OPEN RECALL

NHTSA campaign 19V864000 · 231,664 vehicles affected

Defect

Ford Motor Company (Ford) is recalling certain 2017-2019 Super Duty F-250, F-350, and F-450 trucks equipped with an electric tailgate latch release switch mounted in the tailgate handle. Water may enter the electrical wiring system and cause a short circuit, activating the switch and releasing the tailgate latches.

Consequence

Unintended tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.

Corrective Action

Ford will notify owners, and dealers will modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits and will install a new tailgate handle release switch, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S48.

Headlight1

FREE1 OPEN RECALL

NHTSA campaign 19V808000 · 86,296 vehicles affected

Defect

Ford Motor Company (Ford) is recalling certain 2018-2019 F-250, F-350 and F-450 Super Duty trucks. The Daytime Running Lights (DRL) may not dim when the headlight switch is moved into the On" position. As such

Consequence

DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.

Corrective Action

Ford has notified owners, and dealers will reprogram the Body Control Module (BCM) software, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C10.

Axle Shaft1

FREE1 OPEN RECALL

NHTSA campaign 19V688000 · 28,579 vehicles affected

Defect

Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350 vehicles equipped with electronically locking rear differentials. The passenger side rear axle shaft may fail prematurely due to a material issue.

Consequence

A broken passenger side rear axle could result in a loss of drive power and the inability to hold the vehicle still when in Park. If the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of a crash.

Corrective Action

Ford will notify owners, and dealers will inspect the passenger side rear axle shaft, replacing it as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S31.

Seat1

FREE1 OPEN RECALL

NHTSA campaign 19V633000 · 482,520 vehicles affected

Defect

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer and 2019-2020 Expedition vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back str

Consequence

A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Corrective Action

Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall is expected to begin October 7, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

Engine Block Heater1

FREE1 OPEN RECALL

NHTSA campaign 19V278000 · 131,068 vehicles affected

Defect

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.

Consequence

A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

Corrective Action

Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall is expected to begin April 22, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.

Engine1

FREE1 OPEN RECALL

NHTSA campaign 18V894000 · 410,289 vehicles affected

Defect

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

Consequence

When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring and a fire.

Corrective Action

Ford will notify owners, and dealers will inspect and seal the block heater cable, or replace it, as necessary, free of charge. The recall is expected to begin January 7, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.

Transmission1

FREE1 OPEN RECALL

NHTSA campaign 18V802000 · 4 vehicles affected

Defect

Ford Motor Company (Ford) is recalling certain 2019 Ford F-250 Super Duty, F-350 Super Duty and F-450 Super Duty vehicles. An incorrect transmission case casting may cause the park pawl assembly to not be secured, possibly resulting in unintended vehicle movement.

Consequence

Unintended vehicle movement can increase the risk of a crash.

Corrective Action

Ford will notify owners and dealers will inspect the transmission case, replacing the transmission as necessary, free of charge. The recall is expected to begin December 3, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S36.

Don't Want To Service? Sell Us Your Car!

Frequently Asked Questions

5 common questions answered

What recalls has NHTSA issued for the 2019 Ford F-250 Super Duty?

NHTSA has issued 11 recalls for the 2019 Ford F-250 Super Duty involving the Tire, Axle Assembly, Steering, Structure Roof and Pillars, Tailgate Latch, Headlight, Axle Shaft, Seat, Engine Block Heater, Engine, and Transmission components.
The reported concerns include possible loss of vehicle control, unintended movement, fire risk, reduced occupant protection, lighting concerns, and unexpected tailgate opening.

How do I check if my 2019 Ford F-250 Super Duty has an open recall?

You can check the VIN at NHTSA.gov or get a free VIN check at our service department.
Book an inspection with Larry H. Miller Ford Mesa if you are unsure whether a repair was completed.

How much does a 2019 Ford F-250 Super Duty recall repair cost?

A 2019 Ford F-250 Super Duty recall repair is free at an authorized dealer when the VIN is covered by the recall.
The dealer performs the manufacturer-specified remedy without charging the owner.

Can an independent shop fix a 2019 Ford F-250 Super Duty recall?

No; only an authorized franchise dealer performs the manufacturer remedy at no charge.
Factory-trained technicians use manufacturer procedures and equipment for covered recall repairs.

Does an open recall affect the trade-in value of the 2019 Ford F-250 Super Duty?

Buyers and dealers check recall status, so completing an open recall can help provide a clearer trade-in evaluation.
Visit our trade-in page to begin an appraisal conversation.

Recall Service & Dealership Highlights

Protect Your Truck

NHTSA reports risks involving possible tire sidewall or belt separation, improperly welded or failing axle components, steering lock, unintended tailgate opening, reduced headlight visibility, weakened seat recliners, and unintended vehicle movement. Engine block-heater wiring may also overheat or create a fire risk, while sparks near the B-pillar could ignite materials after a crash. Waiting can leave a known safety concern unresolved and may increase the chance of a crash, injury, cargo loss, or fire. A VIN check identifies whether one or more of these campaigns applies to your truck. If it does, the manufacturer remedy is performed free of charge by an authorized dealer.

Factory-Backed Expertise

Larry H. Miller Ford Mesa gives Mesa drivers a trusted destination for recall service. Our factory-trained technicians follow Ford repair procedures and use manufacturer diagnostic tools to verify the concern and complete the specified remedy. OEM parts and approved repair methods help ensure the work addresses the recalled condition rather than treating only a symptom. Recall repairs are performed at no charge when the VIN is covered. We serve drivers throughout Mesa and nearby communities across the East Valley, including Chandler, Gilbert, Tempe, Apache Junction, and Queen Creek. Visit Larry H. Miller Ford Mesa for professional support from an authorized Ford franchise dealer.

Start With a Free VIN Check

Begin by gathering your VIN and using the schedule service link to request an appointment. Bring the 2019 Ford F-250 Super Duty to Larry H. Miller Ford Mesa so our team can check for open recalls and explain the next step. Schedule service even if you are unsure whether a notice applies or whether a prior repair was completed; the recall check is free. If a campaign is open, the manufacturer remedy is completed at no charge. Contact our Mesa service team at 480-690-1279, and choose a convenient visit time before continuing to drive with an unresolved safety concern.